Ductwork Services in Burleson, TX

How Much Does Ductwork Cost in Burleson?

Ductwork in Burleson starts at $85 for a static pressure diagnostic (waived with any repair). Most homes need 2-5 targeted repairs, not a full duct redesign. We're flat-rate, which means the price quoted before we start is the price you pay at the end. Frosty Club members save 10-15% on every job.

Why Do Burleson Homeowners Trust Frosty's for Ductwork?

Burleson ductwork issues track cleanly to the three eras of housing that make up this Johnson County city. Old Town homes along Renfro Street and the SH-174 corridor date from the 1960s through the 1990s — these brick ranches sit on slab foundations with gray flex duct in the attic that is 30-60 years old, where foil tape has long since failed and insulation has compressed to the point where attic heat at 140-160 degrees bakes directly through the duct wall into the conditioned air. Smoke tests on Old Town systems typically show 25-35% leakage, which translates to $50-$80 per month in wasted Oncor electricity during summer. Hidden Creek and Bailey Lake neighborhoods from the late 1990s and 2000s have newer flex duct with better insulation ratings, but tape-joint leakage at the 15-20 year mark is common and accounts for most of the ductwork calls from these subdivisions.

The number one ductwork complaint in Burleson is the upstairs-hotter-than-downstairs problem, particularly in Hidden Creek and Bailey Lake two-story homes where the builder ran a single trunk line from an attic-mounted air handler to serve both floors through branch runs of varying lengths. A Manual D duct sizing calculation reveals the bottleneck — typically an undersized trunk to the second floor or insufficient return air from the master bedroom. The fix is upsizing the trunk, adding a dedicated return, or in some cases adding balancing dampers to redirect airflow. On Old Town single-story ranches, the problem presents differently: rooms at the far end of the house never reach thermostat temperature because the original duct runs are too long, too small, and too leaky after decades of attic heat exposure. Static pressure testing on these systems often reads 0.7-1.0 inches of water column against a 0.5-inch target.

Every Burleson ductwork job gets before-and-after static pressure readings so you can see the improvement quantified. I do not sell standalone duct insulation — if ducts are deteriorated enough to need insulation work, they need full replacement. I'm Omar Jacobo, EPA 608 Universal certified (#2396328), operating under TACLA126718E with 99 Google reviews at 4.9 stars. Duct sealing is $350 flat ($297.50 for Frosty Club members), duct replacement $700 per run ($595 member), plenum $1,200-$1,500. Se Habla Espanol. Call (469) 251-0858 for a ductwork inspection.

Neighborhoods we serve in Burleson: Old Town Burleson, Hidden Creek, Bailey Lake, Oak Valley Estates, Chisholm Summit, Tallgrass, Alsbury Boulevard corridor, SH-174 corridor, Renfro Street